our products

D&Q Mining is a high-tech company integrating R&D, production and sales. It provides mature products and solutions such as crushers, sand making, milling equipment, mobile crushing stations, etc., for aggregate, mining and waste recycling.

quarry dust as fine aggregate in concrete pdf

(PDF) Study on Performance of Quarry Dust as Fine

The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%, 40%, 60%, 80% partial replacement of

More

Research Article Study on Compressive Strength of Quarry

Research Article Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete K.ShyamPrakash 1 andCh.HanumanthaRao 2 Department of Civil Engineering, PVP Siddhartha Institute of Technology, Kanuru, Vijayawada, Andhra Pradesh, India

More

Studies on Quarry Dust as Partial Replacement of Fine

1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3. From the above results 15% replacement of quarry dust gives high Compressive and Flexural Strength. 4. By using quarry dust wastes instead of conventional

More

(PDF) Study on Compressive Strength of Quarry Dust as Fine

Later, a study on quarry dust as a substitute for fine aggregate and reported that 40 % replacement of fine aggregate by quarry dust has come out with excellent results [20]. Based on an overview

More

(PDF) Study on Compressive Strength of Quarry Dust as Fine

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced

More

Studies on Quarry Dust as Partial Replacement of Fine

1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3. From the above results 15% replacement of quarry dust gives high Compressive and Flexural Strength. 4. By using quarry dust wastes instead of conventional

More

(PDF) Studies on Quarry Dust as Partial Replacement of

Natural sand is most commonly used fine aggregates in the production of concrete possess the problem of acute shortage in many areas. Quarry dust can be used as an economic alternative to the natural sand. In this investigation an attempt is made to

More

(PDF) Study on Compressive Strength of Quarry Dust as Fine

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced

More

Analysis of Concrete Made from Quarry Dust

cement, fine aggregate, coarse aggregate, quarry dust. The examples were casted for M25 grade of concrete by supplanting the cement 0%, 5%, 10%, 15% and 20% by quarry dust and tested for workability by slump test, compressive strength, flexure strength and split tensile test at

More

STUDY OF PARTIAL REPLACEMENT OF FINE AGGREGATE BY U

Quarry dust can be an economic alternative to the river sand. It is a waste obtained during quarrying process. It has very rece ntly gained good attention to be used as an effective fi ller material instead of fine aggregate. In the present study, the hardened and durable properties of concrete using quarry dust were investigated. Figure 4.

More

[PDF] Use of Quarry Dust to Replace Sand in Concrete An

This experimental study presents the variation in the strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature effect on concrete cubes at 100 o C on

More

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete. The introduction of quarry dust for mixing is limited due to its high fineness.

More

Utilization of Stone Dust as Fine Aggregate Replacement in

concrete at different level of fine aggregate with stone dust. The percentage of stone dust was gradually increased in concrete and investigates its effect in sense of workability and compressive strength. The study shows that compressive strength of concrete made using stone dust as fine aggregate replacement having greater value in comparison

More

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY

grade concrete with 0.5 water cement ratio. Quarry dust can be used as fine aggregate, but it has to satisfy the technical requisites like workability and strength. Concrete mixes were tested for compressive strength and split tensile strength of concrete replaced by quarry dust was compared. The aim of the test was to find the

More

(PDF) Stone Dust in Concrete: Effect on Compressive Strength

Concrete of M25 grade was designed for a w/c ratio of 0.48 for the replacement of 10% coarse aggregate with recycled coarse aggregate and replacement of 50, 60 and 70% of fine aggregate

More

(PDF) Suitability of Quarry Dust as Partial Replacement

In the present study, experiments were carried out to study the gradation of aggregates, workability, compressive strength and split tensile strength of concrete made using quarry dust as

More

Investigation of the rebound number and compressive

Two types of fine aggregate are Aggregate River Sand Quarry Dust W0 312 187 1,247 624 0 W25 312 187 1,247 468 156 Investigation of the rebound number and compressive strength of concrete with quarry dust as fine aggregate Author: Sinthaworn Suppachai Subject:

More

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT

The ingredients of concrete consist of cement, fine aggregate and coarse aggregates, water. When the reaction of water with cement takes place hydration process is done and a hard material is formed. In this project work we used quarry rock dust as a partial replacement of fine aggregate

More